West Fraser lumber. File photo.

West Fraser lumber. File photo.

Worker buried in sawdust in a shavings bin at West Fraser B.C. Sawmill

WorksafeBC said rescue was needed on one occasion as the worker was unable to help themself

A worker at the Chasm Sawmill division of West Fraser was buried to about head or chest depth in a wood shavings bin area and needed to be rescued, according to a WorkSafeBC report.

“A worker performing clean up during maintenance type work inside a bin approximately 50 to 80 feet high, 30 feet wide, was engulfed by sawdust and/or wood shavings type recovery waste product,” according to the report. “The need for rescue did arise and the lone worker was engulfed and unable to self-rescue.”

The incident was not immediately reported to the board and between the time of the worker being buried and the conclusion of the full investigation, work resumed.

“This employer did not immediately undertake a preliminary investigation that identified all the unsafe conditions, acts or procedures as far as possible, in order to ensure that work can be continued or resumed,” according to the report. “Also, according to information provided by the employer, another worker was engulfed; however, that worker managed to self-rescue.”

The report notes that West Fraser failed to ensure adequate protection from entrapment or engulfment, a serious health and/or safety hazard.

The worker who entered the wood shavings recovery type bin, “was not provided with and did not wear a lifeline and harness, and was not continuously tended by a standby person who is equipped for and capable of effecting immediate rescue.”

WorkSafeBC was notified approximately one week later during a routine inspection, according to the report.

“This employer failed to ensure the scene of an accident that is reportable under subsection (1) was not disturbed, to permit investigate, and prevent potential injuries or death, and any other worker(s) being engulfed.”

A preliminary investigation report was completed and provided to a WorkSafeBC officer. West Fraser has since developed and performed a risk assessment, developed a safe work procedure for entering the shavings bin and as of Nov. 21 planned an emergency drill for confined space and/or enclosed space within the next 30 days.

Part of the actions includes no entry into the bin unless the material is four feet or less.

“A Vac truck and hose system will be used from outside the bin when materials are greater than four feet.”

The 100 Mile Free Press has contacted West Fraser but has not yet received a response.


newsroom@100milefreepress.net

Like us on Facebook and follow us on Twitter.

Get local stories you won't find anywhere else right to your inbox.
Sign up here

Just Posted

Wainwright Marine Services Ltd.’s “Ingenika” tugboat went missing in the Garner Canal area south and east of Kitimat on Feb. 11, resulting in two deaths and the rescue of a third man. (Wainwright Marine Photo)
Tug union demands Transport Canada protect workers along B.C. coast and rivers

ILWU makes safety demands following the deaths of two men and the rescue of a third

High winds blow wet snow in Prince Rupert on Feb. 24. The region is expecting two to four cm of snow and winds up to 100 km per hour. (Photo: K-J Millar/The Northern View)
High wind warnings for North Coast, up to 4 cm of snow expected

Wet snow makes driving conditions in Prince Rupert slippery

Pink shirt day was celebrated at Pineridge Elementary School by staff and students in a stand against bullying. Mr. Craig, a work-experience student from Charle Hays Secondary School is seen with students in front of the hearts for kindness board on Feb. 24. (Photo: K-J Millar/The Northern View)
Pineridge students stand against bullying

Prince Rupert students in the pink with kindness

A Prince Rupert neighbourhood on Feb. 23, showing various housing with an apartment building development in the background. Housing advocates in the city say affordable housing is scarce.(Photo: K-J Millar/The Northern View)
Prince Rupert Recruitment campaign creates housing availability debate

“There is a serious disconnect here, with the new recruitment campaign,” - Paul Lagace

FILE – A COVID-19 vaccine being prepared. (Olivia Sullivan/Sound Publishing)
B.C. seniors 80 years and older to get COVID vaccine details over next 2 weeks: Henry

Province is expanding vaccine workforce as officials ramp up age-based rollout

Dr. Bonnie Henry talk about the next steps in B.C.'s COVID-19 Immunization Plan during a press conference at Legislature in Victoria, B.C., on Friday, January 22, 2021. THE CANADIAN PRESS/Chad Hipolito
456 new COVID-19 cases in B.C., 2 deaths

Since January 2020, 78,278 have tested positive for the novel coronavirus in B.C.

NDP leader Jagmeet Singh holds a press conference on Parliament Hill in Ottawa on Wednesday, Feb. 24, 2021. THE CANADIAN PRESS/Sean Kilpatrick
NDP will not trigger election as long as pandemic continues: Singh

‘“We will vote to keep the government going’

“Support your city” reads a piece of graffiti outside the Ministry of Finance office. (Jane Skrypnek/News Staff)
Slew of anti-bylaw graffiti ‘unacceptable’ says Victoria mayor, police

Downtown businesses, bylaw office and Ministry of Finance vandalized Wednesday morning

A health-care worker prepares a dose of the Pfizer-BioNTech COVID-19 vaccine at a UHN COVID-19 vaccine clinic in Toronto on Thursday, January 7, 2021. (THE CANADIAN PRESS/Nathan Denette)
Vaccinating essential workers before seniors in B.C. could save lives: experts

A new study says the switch could also save up to $230 million in provincial health-care costs

The late Michael Gregory, 57, is accused of sexually exploiting six junior high students between 1999 and 2005. (Pixabay)
Former Alberta teacher accused of sexually assaulting students found dead in B.C.

Mounties say Michael Gregory’s death has been deemed ‘non-suspicious’

According to a new poll, a majority of Canadians want to see illicit drugs decriminalized. (THE ASSOCIATED PRESS)
Majority of Canadians think it’s high time to decriminalize illicit drugs: poll

More than two-times the B.C. residents know someone who died from an overdose compared to rest of Canada

Photograph By @KAYLAXANDERSON
VIDEO: Lynx grabs lunch in Kamloops

A lynx surprises a group of ducks and picks one off for lunch

(Black Press Media file photo)
B.C. residents can reserve provincial camp sites starting March 8

B.C. residents get priority access to camping reservations in province

Most Read